Recalls (4)
NHTSA lists 4 recall campaigns for the 1991 Chevrolet Blazer. Check whether yours was repaired with NHTSA's free VIN lookup ↗
Only NHTSA and your automaker know whether your specific car was repaired. PlainVIN shows every recall campaign listed for a model year, with the official text and how many cars have been fixed so far.
Check on NHTSA ↗GM/ABS
- Summary
- VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
- Consequence
- IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
- Remedy
- DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
GM/INTERIOR SYSTEMS:SEAT BELTS:LAP:REAR
- Summary
- THESE VEHICLES EXHIBIT A CONDITION IN WHICH A REAR SEAT BELT BUCKLE RELEASE BUTTON CAN STICK IN THE UNLATCHED (DOWN) POSITION UNDER CERTAIN CONDITIONS BECAUSE THE BUCKLE ASSEMBLY CAN MOVE INSIDE THE SEAT BELT COVER. IF THE COVER MOVES FAR ENOUGH, IT CAN CREATE AN INTERFERENCE CONDITION WITH THE LATCH RELEASE BUTTON. WHEN IT DOES, THE SEAT BELT BUCKLE CANNOT BE LATCHED.
- Consequence
- THE REAR BELTS MAY NOT HOLD AN OCCUPANT IN THE EVENT OF A VEHICLE ACCIDENT INCREASING THE RISK OF PESONAL INJURY.
- Remedy
- DEALERS WILL REPLACE THE THREE REAR-SEAT BELT BUCKLES (ONE ASSEMBLY) WITH A NEW, REVISED DESIGN.
BRAKES:HYDRAULIC:DISC:ROTOR:DISC HUB
- Summary
- SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
- Consequence
- SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
- Remedy
- REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
FUEL:FUEL SYSTEM OTHER PARTS
- Summary
- VEHICLES HAVE BEEN SHIPPED WITH THE FUEL TANK SENDER SEAL OUT OF POSITION.
- Consequence
- IN THE EVENT OF ROLLOVER ACCIDENT, AN OUT OF POSTIONSEAL COULD ALLOW FUEL SPILLAGE IN EXCESS OF THE AMOUNT PRESCRIBED BY FMVSS 301.SPILLED FUEL COULD IGNITE NEAR AN IGNITION SOURCE.
- Remedy
- REPLACE SENDER SEALS.
PlainVIN shows public government records for education. It isn't a vehicle inspection or legal advice. Check your own VIN with NHTSA or your dealer.
Owner complaints (222)
222 complaints filed with NHTSA (owner reports, not verified findings). The service brakes is mentioned most often.
As reported by owners in their complaints. These are reports, not NHTSA findings.
Most-reported components
| Component | Complaints | % of 222 |
|---|---|---|
| Service brakes | 128 | 57.7% |
| Seat belts | 26 | 11.7% |
| Electrical system | 16 | 7.2% |
| Engine and engine cooling | 12 | 5.4% |
| Vehicle speed control | 11 | 5% |
| Power train | 8 | 3.6% |
| Fuel system | 7 | 3.2% |
| Seats | 7 | 3.2% |
| Steering | 5 | 2.3% |
| Suspension | 5 | 2.3% |
How 1991 compares with other Blazer years
Best and worst Blazer years →| Model year | Complaints | Recall campaigns |
|---|---|---|
| 1987 | 30 | 0 |
| 1988 | 40 | 1 |
| 1989 | 38 | 1 |
| 1990 | 32 | 1 |
| 1991 | 222 | 4 |
| 1992 | 278 | 2 |
| 1993 | 511 | 2 |
| 1994 | 620 | 2 |
| 1995 | 1,224 | 6 |
| 1996 | 1,153 | 6 |
Counts are owner reports, not failure rates. Higher sales years tend to draw more reports. Owners are still filing reports for recent model years, so these counts will grow. Source: NHTSA ODI, retrieved Oct 6, 2026.
Fuel economy: up to 18 mpg combined
- EPA annual fuel cost
- $3,700
- CO₂ tailpipe
- 494 g/mi
- EPA class
- Special Purpose Vehicle
What it costs you to run
Miles ÷ 18 mpg × $4.354 (EIA US average regular, week of Oct 5, 2026, all taxes included). Source: EPA · EIA.
EPA label estimates from lab tests; your mileage will vary.
Specs by configuration
| Engine · transmission | Drive | City / Hwy / Comb | EPA $/yr | CO₂ g/mi |
|---|---|---|---|---|
| 4.3 L 6-cyl · 4-speed automatic | Rear-Wheel Drive | 16 / 22 / 18 | $3,700 | 494 |
| 4.3 L 6-cyl · 5-speed manual | Rear-Wheel Drive | 15 / 22 / 18 | $3,700 | 494 |
| 4.3 L 6-cyl · 4-speed automatic | 4-Wheel or All-Wheel Drive | 15 / 20 / 17 | $3,950 | 523 |
| 6.2 L 8-cyl · 4-speed automatic | 4-Wheel or All-Wheel Drive | 15 / 20 / 17 | $5,650 | 599 |
| 4.3 L 6-cyl · 5-speed manual | 4-Wheel or All-Wheel Drive | 14 / 18 / 16 | $4,200 | 555 |
| 5.7 L 8-cyl · 4-speed automatic | 4-Wheel or All-Wheel Drive | 11 / 15 / 13 | $5,150 | 684 |
| 5.7 L 8-cyl · 4-speed manual | 4-Wheel or All-Wheel Drive | 11 / 13 / 12 | $5,600 | 741 |
Source: EPA fuel economy data, retrieved Oct 6, 2026. Configurations are listed when EPA and NHTSA records match.
Looking at a 1991 Blazer for sale?
Print a one-page buyer's checklist: each recall campaign with a box to tick when the seller shows proof of repair, the top complaint areas to inspect, crash stars, MPG, and a link back to this page.
Where to next
1991 Chevrolet Blazer FAQ
How many recalls does the 1991 Chevrolet Blazer have?
NHTSA lists 4 recall campaigns: 99V193000 (brake), 96V142000 (seat belt), 93V119000 (brake), 91V108000 (fuel system). Use NHTSA's VIN lookup to see whether a specific car was repaired.
What are the most common 1991 Chevrolet Blazer problems?
Owners filed 222 complaints with NHTSA. Service brakes (128), Seat belts (26), Electrical system (16) are mentioned most. These are owner reports, not verified findings.
What mpg does the 1991 Chevrolet Blazer get?
EPA rates the 4.3 L 6-cyl · 4-speed automatic version at 16 city, 22 highway and 18 combined mpg. Other configurations are listed in the fuel economy section.
How does the 1991 Blazer compare with other years?
Among the 1987–1996 Chevrolet Blazer model years at least five years old, the 1987 drew the fewest complaints (30) and the 1995 the most (1,224). The 1991 drew 222. Counts are owner reports, not failure rates.
How this page was madeSources, processing, limits, review and changes
Data sources
- NHTSA recalls by vehicle
Retrieved Oct 6, 2026 - US DOT recall completion rates (data.transportation.gov)
Retrieved Oct 6, 2026 - NHTSA ODI owner complaints
Retrieved Oct 6, 2026 - NHTSA NCAP 5-Star Safety Ratings
Retrieved Oct 6, 2026 - EPA fuel economy data (licence confirmation pending)
Retrieved Oct 6, 2026 - EIA weekly retail gasoline prices
Weekly, all taxes included
Processing
- Complaints are counted per component. One complaint can list several, so component totals add up to more than the total.
- Fuel cost = miles per year ÷ EPA combined mpg × EIA weekly price for your region.
Limitations
- Complaint counts are owner reports, not verified findings or failure rates. There is no sales denominator.
- Recall campaigns are listed for the model year. Only NHTSA and the automaker know whether a specific car was repaired.
- Recent model years are still collecting reports.
Review
Data compiled automatically from the official files listed here.
Changelog
- 2026-10-06 Data refreshed from the official files.