Recalls (4)
NHTSA lists 4 recall campaigns for the 2002 Chevrolet Silverado. Check whether yours was repaired with NHTSA's free VIN lookup ↗
Only NHTSA and your automaker know whether your specific car was repaired. PlainVIN shows every recall campaign listed for a model year, with the official text and how many cars have been fixed so far.
Check on NHTSA ↗Listed for 2002 Chevrolet Silverado. Not checked against your VIN.
UNWANTED ABS ACTIVATION
Service brakes, hydraulic · antilock/traction control/electronic limited slip
Official NHTSA text
- Summary
- CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
- Consequence
- THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
- Remedy
- DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Repair progress not yet reported1,353,718 vehicles potentially affected
Manufacturer report to NHTSA · Source: US DOT recall completion data, retrieved Oct 6, 2026
Check your VIN on NHTSA
or ask a dealer to check campaign 05V379000
Listed for 2002 Chevrolet Silverado. Not checked against your VIN.
PARKING BRAKE SYSTEM
Parking brake
Official NHTSA text
- Summary
- ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
- Consequence
- IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
- Remedy
- DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Repair progress not yet reported90,242 vehicles potentially affected
Manufacturer report to NHTSA · Source: US DOT recall completion data, retrieved Oct 6, 2026
Check your VIN on NHTSA
or ask a dealer to check campaign 05V161000
Listed for 2002 Chevrolet Silverado. Not checked against your VIN.
GM/TAILGATE SUPPORT CABLE
Structure · body · tailgate · hinge and attachments
Official NHTSA text
- Summary
- ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
- Consequence
- ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
- Remedy
- DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Repair progress not yet reported3,662,211 vehicles potentially affected
Manufacturer report to NHTSA · Source: US DOT recall completion data, retrieved Oct 6, 2026
Check your VIN on NHTSA
or ask a dealer to check campaign 04V129000
Listed for 2002 Chevrolet Silverado. Not checked against your VIN.
GM/CNG FUEL LEAKAGE
Fuel system, other · delivery
Official NHTSA text
- Summary
- SOME 2WD AND 4WD PICKUP TRUCKS, CONVERTED TO EITHER DEDICATED OR BI-FUEL COMPRESSED NATURAL GAS (CNG) FUEL USAGE, WERE ASSEMBLED WITH A THROTTLE CABLE THAT CAN CONTACT AND RUB THROUGH THE FLEXIBLE PRESSURIZED FUEL LINE CREATING A PINHOLE LEAK OF NATURAL GAS TO THE ATMOSPHERE.
- Consequence
- A STRONG ODOR OF NATURAL GAS MAY BE DETECTED FROM INSIDE THE VEHICLE, POSSIBLY ACCOMPANIED BY A HISSING NOISE. IF THE NATURAL GAS WERE ACCIDENTALLY IGNITED, SERIOUS INJURY COULD RESULT.
- Remedy
- DEALERS WILL SECURE THE THROTTLE CABLE TO ELIMINATE THE POSSIBILITY OF CONTACT WITH THE CNG FUEL LINE. THE CNG FUEL LINE, THROTTLE CABLE, AND CRUISE CONTROL CABLE ARE ALSO TO BE INSPECTED AND REPLACED IF NECESSARY. OWNER NOTIFICATION BEGAN ON DECEMBER 11, 2003. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Repair progress not yet reported395 vehicles potentially affected
Manufacturer report to NHTSA · Source: US DOT recall completion data, retrieved Oct 6, 2026
Check your VIN on NHTSA
or ask a dealer to check campaign 03V435000
PlainVIN shows public government records for education. It isn't a vehicle inspection or legal advice. Check your own VIN with NHTSA or your dealer.
Owner complaints (710)
710 complaints filed with NHTSA (owner reports, not verified findings). The service brakes is mentioned most often.
75involved a crash
5involved a fire
47injuries reported
1deaths reported
As reported by owners in their complaints. These are reports, not NHTSA findings.
Most-reported components
| Component | Complaints | % of 710 |
|---|---|---|
| Service brakes | 328 | 46.2% |
| Power train | 70 | 9.9% |
| Engine and engine cooling | 58 | 8.2% |
| Steering | 39 | 5.5% |
| Structure | 36 | 5.1% |
| Air bags | 30 | 4.2% |
| Parking brake | 30 | 4.2% |
| Suspension | 29 | 4.1% |
| Tires | 27 | 3.8% |
| Electrical system | 25 | 3.5% |
How 2002 compares with other Silverado years
Best and worst Silverado years →1998279
19991,660
20001,305
2001877
2002710
2003695
2004622
2005316
2006182
2007183
| Model year | Complaints | Recall campaigns |
|---|---|---|
| 1998 | 279 | 0 |
| 1999 | 1,660 | 5 |
| 2000 | 1,305 | 8 |
| 2001 | 877 | 4 |
| 2002 | 710 | 4 |
| 2003 | 695 | 6 |
| 2004 | 622 | 8 |
| 2005 | 316 | 8 |
| 2006 | 182 | 4 |
| 2007 | 183 | 1 |
This year (2002)Other yearsStill collecting reports
Counts are owner reports, not failure rates. Higher sales years tend to draw more reports. Owners are still filing reports for recent model years, so these counts will grow. Source: NHTSA ODI, retrieved Oct 6, 2026.
Looking at a 2002 Silverado for sale?
Print a one-page buyer's checklist: each recall campaign with a box to tick when the seller shows proof of repair, the top complaint areas to inspect, crash stars, MPG, and a link back to this page.
Where to next
2002 Chevrolet Silverado FAQ
How many recalls does the 2002 Chevrolet Silverado have?
NHTSA lists 4 recall campaigns: 05V379000 (brake), 05V161000 (brake), 04V129000 (structure), 03V435000 (fuel system). Use NHTSA's VIN lookup to see whether a specific car was repaired.
What are the most common 2002 Chevrolet Silverado problems?
Owners filed 710 complaints with NHTSA. Service brakes (328), Power train (70), Engine and engine cooling (58) are mentioned most. These are owner reports, not verified findings.
How does the 2002 Silverado compare with other years?
Among the 1998–2007 Chevrolet Silverado model years at least five years old, the 2006 drew the fewest complaints (182) and the 1999 the most (1,660). The 2002 drew 710. Counts are owner reports, not failure rates.
How this page was madeSources, processing, limits, review and changes
Data sources
- NHTSA recalls by vehicle
Retrieved Oct 6, 2026 - US DOT recall completion rates (data.transportation.gov)
Retrieved Oct 6, 2026 - NHTSA ODI owner complaints
Retrieved Oct 6, 2026 - NHTSA NCAP 5-Star Safety Ratings
Retrieved Oct 6, 2026 - EPA fuel economy data (licence confirmation pending)
Retrieved Oct 6, 2026 - EIA weekly retail gasoline prices
Weekly, all taxes included
Processing
- Complaints are counted per component. One complaint can list several, so component totals add up to more than the total.
- Fuel cost = miles per year ÷ EPA combined mpg × EIA weekly price for your region.
Limitations
- Complaint counts are owner reports, not verified findings or failure rates. There is no sales denominator.
- Recall campaigns are listed for the model year. Only NHTSA and the automaker know whether a specific car was repaired.
- Recent model years are still collecting reports.
Review
Data compiled automatically from the official files listed here.
Changelog
- 2026-10-06 Data refreshed from the official files.
Was this report useful?Report a data error